Guest ThisPlaceSucks Posted January 5, 2011 Report Share Posted January 5, 2011 Hey OFNers...Trying to get out and enjoy what little snow we have on the lakes up here... Seems somewhere in the my travels the last few days my headlight, tach, and console lights stopped working... electric start and RER are still functioning. The fuses appear to all be fine. What do you guys think is the problem? Regulator? Relay? Something else? Link to comment Share on other sites More sharing options...
aplumma Posted January 5, 2011 Report Share Posted January 5, 2011 Check the connections and replace the good looking fuse. Their should not be a relay or regulator in that circuit. Art Link to comment Share on other sites More sharing options...
skeeter Posted January 5, 2011 Report Share Posted January 5, 2011 also reach up under the back of the ignition and wiggle the wires there. and like aplumma said replace the fuses that even look good , i have been down that road-LOL Link to comment Share on other sites More sharing options...
lakerguy Posted January 5, 2011 Report Share Posted January 5, 2011 If its a rev,check the relay, black cube above secondary Link to comment Share on other sites More sharing options...
Fisherman Posted January 5, 2011 Report Share Posted January 5, 2011 Dr. S, had a very similar problem on an 04 Skandic, rear light, fuel gauge and tach running spordically. Ended up being a bare chaffed wire that runs through the tube along side the running board, it was a real pain to diagnose, the bare part was facing down and if I hadn't seen a tiny spark while rattling things, I was ready to take the big hammer out. Link to comment Share on other sites More sharing options...
Sharkbait22 Posted January 5, 2011 Report Share Posted January 5, 2011 Good suggestions. Check the socket connections. Hit the socket with some grease. As said, replace the fuse. Get a volt meter on it. Is there voltage to the light? Is the circuit grounded out? Good luck. Link to comment Share on other sites More sharing options...
12footspringbok Posted January 6, 2011 Report Share Posted January 6, 2011 Voltage Regulator. Link to comment Share on other sites More sharing options...
Old Man Posted January 6, 2011 Report Share Posted January 6, 2011 Did the lights get brighter then burn out. If so, you voltage regulator is shot. If the bulbs are still good, it could be a faulty lighting coil in the magneto. Link to comment Share on other sites More sharing options...
trapshooter Posted January 6, 2011 Report Share Posted January 6, 2011 If I remember right, you have a 02-03 Skidoo Grand Touring? Nearly the same as mine. I had the same issues last year and it was the voltage regulator. Not a cheap part either. Good luck. Link to comment Share on other sites More sharing options...
discophish Posted January 6, 2011 Report Share Posted January 6, 2011 (edited) I would say for sure it's the regulator. Actually, I just checked my Yamaha Venture .pdf service manual, and yup, it's the regulator. I bet your tail lights are on the same circuit. Hope it's only a scuffed wire though! Regulators aren't cheap. Good luck Edited January 6, 2011 by Disco Phish Link to comment Share on other sites More sharing options...
lakerguy Posted January 6, 2011 Report Share Posted January 6, 2011 (edited) http://www.royaldistributing.com/main/index.php?option=com_flippingbook&view=book&id=14&Itemid=419&firstPageNumber=98 If it is a volt reg.there not too badly priced here.Not sure what a dealer would cost... Volt regs are on pg 106 Edited January 6, 2011 by lakerguy Link to comment Share on other sites More sharing options...
Guest ThisPlaceSucks Posted January 6, 2011 Report Share Posted January 6, 2011 http://www.royaldistributing.com/main/index.php?option=com_flippingbook&view=book&id=14&Itemid=419&firstPageNumber=98 If it is a volt reg.there not too badly priced here.Not sure what a dealer would cost... about 100 dollars just to walk in the door! Link to comment Share on other sites More sharing options...
Kerry Posted January 7, 2011 Report Share Posted January 7, 2011 Royal might be cheaper but after going thru two coils on my old arctic cat in one year because the wires couldn't take any vibration at all I gave up and bought a factory one.Never had a problem after that.Cheap chinese made junk. Kerry Link to comment Share on other sites More sharing options...
BrownTown Posted January 7, 2011 Report Share Posted January 7, 2011 Could be the voltage regulator or check the wiring harness..Not sure of it was those sleds but some were coming in contact with the exhaust and shorting out. Link to comment Share on other sites More sharing options...
Old Man Posted January 7, 2011 Report Share Posted January 7, 2011 (edited) If you have an ohm meter, you can easily test the lighting coil(s) on the stator. Attached is a link to video on You Tube explaining how to test stators. http://www.google.ca...hc8Rhyw&cad=rja It could be the Voltage Regulator, but if it is, it's likely that you would have blown some or all of the lights on your sled. Edited January 7, 2011 by Old Man Link to comment Share on other sites More sharing options...
brickNblock Posted January 7, 2011 Report Share Posted January 7, 2011 Hey Doc, like most the others have said...voltage regulator but first... wiggle some wires...it actualy works and when you find one that does the trick..take it apart and clean it up/connections too.. Most of the time I found it to just be spark tho.....They sit for so long oper the non-snow months and water=rust Link to comment Share on other sites More sharing options...
Guest ThisPlaceSucks Posted January 7, 2011 Report Share Posted January 7, 2011 Just to clarify the symptoms, no lights are working. the only thing electrical that works is the electric start and RER, but because the battery is draining, they don't work now either. could this problem be affecting my sparkplugs as well? went to load the sled on the trailer and it will idle fine, but when i apply throttle it pops and loses power like it's not getting a proper spark... hopefully going to be serviced soon! no sled makes me sad! Link to comment Share on other sites More sharing options...
Old Man Posted January 7, 2011 Report Share Posted January 7, 2011 (edited) Just to clarify the symptoms, no lights are working. the only thing electrical that works is the electric start and RER, but because the battery is draining, they don't work now either. could this problem be affecting my sparkplugs as well? went to load the sled on the trailer and it will idle fine, but when i apply throttle it pops and loses power like it's not getting a proper spark... hopefully going to be serviced soon! no sled makes me sad! It's the lighting coil on the stator. It provides all the power to run lights, accessories, and charges the battery. Edited January 7, 2011 by Old Man Link to comment Share on other sites More sharing options...
DRIFTER_016 Posted January 7, 2011 Report Share Posted January 7, 2011 It's the lighting coil on the stator. It provides all the power to run light, accessories, and charges the battery. Yep, sure sounds like it, or the regulator. Check the light bulbs with an ohm meter and if the bulbs read as open it's the regulator. If the bulbs are good it's most likely the coil. Link to comment Share on other sites More sharing options...
Guest ThisPlaceSucks Posted January 10, 2011 Report Share Posted January 10, 2011 well, to the great minds guiding me towards the regulator and the stator, you were both right! both are faulty and in need of replacement. 500 dollars in parts! Link to comment Share on other sites More sharing options...
Old Man Posted January 10, 2011 Report Share Posted January 10, 2011 well, to the great minds guiding me towards the regulator and the stator, you were both right! both are faulty and in need of replacement. 500 dollars in parts! Ouch Link to comment Share on other sites More sharing options...
DRIFTER_016 Posted January 10, 2011 Report Share Posted January 10, 2011 Yep, toy parts ain't cheap. I had to replace the stator assy. on my '89 CR125 Honda for the nifty sum of $600 once. Wasn't too impressed either. Never had another problem with the bike after I replaced it though. Link to comment Share on other sites More sharing options...
Guest ThisPlaceSucks Posted January 10, 2011 Report Share Posted January 10, 2011 mine was 300 but i was told that some arctic cat stators go for 900 bucks so i guess i should feel fortunate? be nice to have her back regardless... winter's too short as it is! Link to comment Share on other sites More sharing options...
Recommended Posts
Create an account or sign in to comment
You need to be a member in order to leave a comment
Create an account
Sign up for a new account in our community. It's easy!
Register a new accountSign in
Already have an account? Sign in here.
Sign In Now